Stage Kit Tsb
Thread Starter
Senior Member
Joined: 04-28-05
Posts: 1,726
Likes: 0
From: baltimore md
Stage Kit Tsb
Subject: GM Performance Parts Stage 1 or 2 Kits Only - SES Light with a P0171 DTC and NO Engine Performance Issues - keywords supercharger #PIP3868 - (07/25/2006)
Models: 2005-2007 Chevrolet Cobalt SS
2004-2007 Saturn Ion Redline
with 2.0L Engine (VIN P - RPO LSJ)
and a Dealer Installed GM Performance
Parts Stage 1 or Stage 2 Kit
--------------------------------------------------------------------------------
The following diagnosis might be helpful if the vehicle exhibits the symptom(s) described in this PI.
Condition/Concern:
On rare occasions, an intermittent SES light may be encountered with a DTC P0171 but NO engine performance concerns will exist.
Important: This PI only applies to vehicles that have a GM Performance Parts Stage 1 or Stage 2 Kit installed. For vehicles without a GM Performance Parts Stage 1 or Stage 2 Kit, see bulletin 06-06-04-033.
Recommendation/Instructions:
If there are no engine performance concerns, vacuum leaks, inaccurate ECM inputs, or fuel system/air filter issues present and the SI diagnostics do not isolate a cause for this concern, no repairs should be performed.
This issue is currently under investigation. Once a repair is developed, this PI will be updated with the related repair information and a Proactive message will be sent to all dealers with open TAC cases that refer to this PI.
Please follow this diagnostic or repair process thoroughly and complete each step. If the condition exhibited is resolved without completing every step, the remaining steps do not need to be performed.
Models: 2005-2007 Chevrolet Cobalt SS
2004-2007 Saturn Ion Redline
with 2.0L Engine (VIN P - RPO LSJ)
and a Dealer Installed GM Performance
Parts Stage 1 or Stage 2 Kit
--------------------------------------------------------------------------------
The following diagnosis might be helpful if the vehicle exhibits the symptom(s) described in this PI.
Condition/Concern:
On rare occasions, an intermittent SES light may be encountered with a DTC P0171 but NO engine performance concerns will exist.
Important: This PI only applies to vehicles that have a GM Performance Parts Stage 1 or Stage 2 Kit installed. For vehicles without a GM Performance Parts Stage 1 or Stage 2 Kit, see bulletin 06-06-04-033.
Recommendation/Instructions:
If there are no engine performance concerns, vacuum leaks, inaccurate ECM inputs, or fuel system/air filter issues present and the SI diagnostics do not isolate a cause for this concern, no repairs should be performed.
This issue is currently under investigation. Once a repair is developed, this PI will be updated with the related repair information and a Proactive message will be sent to all dealers with open TAC cases that refer to this PI.
Please follow this diagnostic or repair process thoroughly and complete each step. If the condition exhibited is resolved without completing every step, the remaining steps do not need to be performed.
Senior Member
Joined: 07-06-04
Posts: 2,082
Likes: 2
From: Spaceball 1 or better known as CT
that is the same tsb they sent out for std cobalt ss s/c with these codes, supposedly there is a reflash that came out june for that but no word on a reflash for staged cars...
Banned
Joined: 05-12-05
Posts: 2,698
Likes: 0
From: Nebraska
So what " problems " are people having with the stage kits? All I see on .com is a bunch of people saying not to buy it or that it has problems.
Is turning a SS/SC into a fully warrantied rocket a problem now?
Is turning a SS/SC into a fully warrantied rocket a problem now?
Thread
Thread Starter
Forum
Replies
Last Post
Jesse
Problems/Service/Maintenance
2
Sep 28, 2015 12:51 PM
